（1） Mixing drum

1. 日常檢查攪拌筒拖輪，有無破損、松動及不正常聲音。每月加一次潤滑脂。

1. Daily check the mixing drum tug for damage, looseness and abnormal sound. Add grease once a month.

2. 日常檢查攪拌筒滾道，有無磨損、損傷及焊縫開裂。適時加涂潤滑脂，涂一薄層。

2. Daily check the mixing drum raceway for wear, damage and weld cracking. Timely apply lubricating grease and a thin layer.

3. 攪拌筒內部經常性沖洗，鏟刮粘著的混凝土。

3. Wash the inside of the mixing drum regularly and scrape the adhered concrete.

（二）混凝土攪拌罐車驅動系統

（2） Driving system of concrete mixing tank truck

1. 日常檢查減速機有無漏油，油量是否足夠，油內是否有雜質。初次換油時間為500工作小時，以后每2000工作小時或一年換一次油。

1. Check the reducer for oil leakage, oil quantity and impurities. The first oil change time is 500 working hours, and then every 2000 working hours or once a year.

2. 每三個月檢查傳動軸法蘭螺栓有無松動，十字軸萬向節有無松動，每月加注一次潤滑脂。

2. Every three months, check whether the flange bolts of the transmission shaft are loose and whether the universal joint of the cross shaft is loose, and add grease once a month.

（三）混凝土攪拌罐車操縱系統

（3） Control system of concrete mixing tank truck

操縱是否正常、靈活，每月加注一次潤滑脂，相對運動表面加涂潤滑脂。

If the operation is normal and flexible, add grease once a month, and apply grease to the relative moving surface.

（四）混凝土攪拌罐車液壓系統

（4） Hydraulic system of concrete mixing tank truck

1. 每六個月檢查油箱、加油口，有無污垢、漏油、油量是否足夠，清洗、修整、加油，補油或換油時必須經過過濾裝置過濾。

1. Check the oil tank and oil filling port every six months for dirt, oil leakage and sufficient oil quantity. Clean, repair, add oil, and make up or change oil must be filtered by the filter device.

2. 日常檢查油泵、馬達、各類閥及其接頭，有無漏油、損傷。擰緊或更換油標。

2. Daily check the oil pump, motor, various valves and their joints for oil leakage and damage. Tighten or replace the oil level.

（五）混凝土攪拌罐車供水系統

（5） Water supply system of concrete mixing tank truck

1. 日常檢查水管、接頭有無漏水，收緊管箍或更換。

1. Daily check water pipes and joints for water leakage, tighten pipe hoops or replace them.

2. 日常檢查閥門是否轉動靈活，修整或更換。

2. Daily check whether the valve can rotate flexibly, repair or replace.

本文由自上料混凝土攪拌罐車為您提供，我們的網站是：http://www.hu198.com將以全心全意的熱情為您提供服務，歡迎您的訪問！

This article is provided by Zhongke Jufeng concrete mixer. Our website is: http://www.hu198.com We will serve you wholeheartedly and warmly. Welcome to visit!